Standard Historical Last Updated: Dec 31, 2010 Track Document
ASTM D471-06e1

Standard Test Method for Rubber Property—Effect of Liquids

Standard Test Method for Rubber PropertyEffect of Liquids D0471-06E01 ASTM|D0471-06E01|en-US Standard Test Method for Rubber PropertyEffect of Liquids Standard new BOS Vol. 09.01 Committee D11
$ 83.00 In stock

Significance and Use

Certain rubber articles, for example, seals, gaskets, hoses, diaphragms, and sleeves, may be exposed to oils, greases, fuels, and other fluids during service. The exposure may be continuous or intermittent and may occur over wide temperature ranges.

Properties of rubber articles deteriorate during exposure to these liquids, affecting the performance of the rubber part, which can result in partial failure.

This test method attempts to simulate service conditions through controlled accelerated testing, but may not give any direct correlation with actual part performance, since service conditions vary too widely. It yields comparative data on which to base judgment as to expected service quality.

This test method is suitable for specification compliance testing, quality control, referee purposes, and research and development work.

Scope

1.1 This test method covers the required procedures to evaluate the comparative ability of rubber and rubber-like compositions to withstand the effect of liquids. It is designed for testing: (1) specimens of vulcanized rubber cut from standard sheets (see Practice D 3182), (2) specimens cut from fabric coated with vulcanized rubber (see Test Methods D 751), or (3) finished articles of commerce (see Practice D 3183). This test method is not applicable to the testing of cellular rubbers, porous compositions, and compressed sheet packing, except as described in 11.2.2.

1.2 ASTM Oils No. 2 and No. 3, formerly used in this test method as standard test liquids, are no longer commercially available and in 1993 were replaced with IRM 902 and IRM 903, respectively (see Appendix X1 for details).

1.3 ASTM No. 1 Oil, previously used in this test method as a standard test liquid, is no longer commercially available and in 2005 was replaced with IRM 901; refer to Table 1, Footnote A, and Appendix X3 for details.

1.4 This test method includes the following:

Change in Mass (after immersion)Section 10
Change in Volume (after immersion)Section 11
Dimensional-Change Method for Water-Insoluble Liq-
uids and Mixed Liquids

Section 12
Change in Mass with Liquid on One Surface OnlySection 13
Determining Mass of Soluble Matter Extracted by the
Liquid

Section 14
Change in Tensile Strength, Elongation and Hardness
(after immersion)

Section 15
Change in Breaking Resistance, Burst Strength, Tear
Strength and Adhesion for Coated Fabrics

Section 16
Calculation (of test results)Section 18

1.5 The values stated in SI units are to be regarded as the standard. The values in parentheses are for information only.

1.6 This standard does not purport to address all of the safety concerns, if any, associated with its use. It is the responsibility of the user of this standard to establish appropriate safety and health practices and determine the applicability of regulatory limitations prior to use.

TABLE 1 Specifications and Typical Properties of ASTM and IRM Reference Oils

PropertyASTM Oil No. 1AASTM Oil No. 5IRM 901 IRM 902IRM 903ASTM Method
Specified Properties:
Aniline Point, °C (°F) 124 ± 1 (255 ± 2) 115 ± 1 (239± 2) 124 ± 1 (255 ± 2) 93 ± 3 (199 ± 5) 70± 1 (158 ± 2) D 611
Kinematic Viscosity
(mm2/s [cSt])
38°C (100°F) ... ... ... 31.934.1 D 445
99°C (210°F) 18.721.0 10.811.9 18.1220.34 19.221.5 ... D 445
Gravity, API, 16°C (60°F) ... ... 28.8 ± 1 19.021.0 21.023.0 D 287
Viscosity-Gravity Constant ... ... 0.7900.805 0.8600.870 0.8750.885 D 2140
Flash Point COC, °C (°F) 243 (469) min 243 (469) min 243(469) min 240 (464) min 163 (325) min D 92
Naphthenics, CN (%) ... ... 27 (avg) 35 min 40 min D 2140
Paraffinics, CP (%) ... ... 65 min 50 max 45 max D 2140
Typical Properties:
Pour Point, °C (°F) ... 15 (5) 12 (10) 12 (10) 31 (24) D 97
ASTM Color ... L 1.0 L 3.5 L 2.5 L 0.5 D 1500
Refractive Index ... 1.4808 1.4848 1.5105 1.5026 D 1747
UV Absorbance, 260 nm ... ... 0.8 4.0 2.2 D 2008
Aromatics, CA (%) ... 4 3 12 14 D 2140

A ASTM Oil No. 1 is no longer commercially available, the specifications are left in place for the purpose of reference until such time as an interlaboratory test program is conducted to determine precision and bias. Refer to Appendix X3.

Price:
Contact Sales
Related
Reprints and Permissions
Reprints and copyright permissions can be requested through the
Copyright Clearance Center
Details
Book of Standards Volume: 09.01
Developed by Subcommittee: D11.15
Pages: 13
DOI: 10.1520/D0471-06E01
ICS Code: 83.060